Carrier 794 Bedienungsanleitung

Models 750/751/754/774/794Soft Serve FreezersOperating Instructions028754--M2/01/02

6Models 750, 751, 754, 774, 794Operator Parts IdentificationModel 754Item Description Part No.1 Cover A.-Hopper X384582 Gasket-Hopper Cover 0384743 Tu

7Models 750, 751, 754, 774, 794 Operator Parts IdentificationModel 774Item Description Part No.1 Cover A.-Hopper X384582 Gasket-Hopper Cover 0384743 T

8Models 750, 751, 754, 774, 794Operator Parts IdentificationModel 774 Topping Pump (053794--)ITEM DESCRIPTION PART NO.1 Knob -Plunger-Tan 032762-TAN1

9Models 750, 751, 754, 774, 794 Operator Parts IdentificationModel 794Item Description Part No.1 Cover-Hopper 14 Qt. Grey 041682-GRY2 Pan-Drip 19-1/2

10Models 750, 751, 754, 774, 794Operator Parts IdentificationModels 750 & 751 Single Spout Door and Beater AssemblyITEM DESCRIPTION PART NO.1 HAND

11Models 750, 751, 754, 774, 794 Operator Parts IdentificationModels 754, 774 & 794 Three Spout Door and Beater AssemblyItem Description Part No.1

12Models 750, 751, 754, 774, 794Important: To the OperatorSection 5 Important: To the Operator750/751754/774/794ITEM DESCRIPTION1 MIX LOW INDICATOR LI

13Models 750, 751, 754, 774, 794 Important: To the OperatorThe following chart identifies the symbol definitions.=OFF=ON=MIX= STANDBY= WASH=AUTOPower

14Models 750, 751, 754, 774, 794Important: To the OperatorReset ButtonOn counter models, the reset button is located on theside of the unit. On consol

15Models 750, 751, 754, 774, 794 Operating ProceduresSection 6 Operating ProceduresThe Model 751 has been selected to illustrate thestep-by-step opera

Complete this page for quick reference when service is required:Taylor Distributor:Address:Phone:Service:Parts:Date of Installation:Information found

16Models 750, 751, 754, 774, 794Operating ProceduresInsert the drive shaft into the freezing cylinder , hex endfirst, and into the rear shell bearing

17Models 750, 751, 754, 774, 794 Operating ProceduresNote: There are two gaskets and two front bearingsfor the Models 754, 774, and 794 door, one for

18Models 750, 751, 754, 774, 794Operating ProceduresStep 5Install the draw valve(s). Slide the two o-rings into thegrooves on the draw valve(s), and l

19Models 750, 751, 754, 774, 794 Operating ProceduresStep 7Snap the design cap(s) over the end of the doorspout(s).Figure 16Step 8Install the front dr

20Models 750, 751, 754, 774, 794Operating ProceduresInstall the air orifice into the hole in the top of the airtube (in the end without the small hole

21Models 750, 751, 754, 774, 794 Operating ProceduresFigure 25Step 4Place the power switch in the ON position.Figure 26Step 5Press the WASH key. This

22Models 750, 751, 754, 774, 794Operating ProceduresStep 9Assemble the hopper gasket around the top edge ofthe mix hopper. Stand the air tube in the c

23Models 750, 751, 754, 774, 794 Operating ProceduresStep 7Place the mix hopper cover in position over the mixhopper.Repeat steps 1 through 7 for the

24Models 750, 751, 754, 774, 794Operating ProceduresRepeat steps 1 through 7 for the other side of thefreezer on Models 754, 774 and 794.DisassemblyMA

25Models 750, 751, 754, 774, 794 Important: Operator ChecklistSection 7 Important: Operator ChecklistDuring Cleaning and SanitizingCleaning and saniti

Models 750, 751, 754, 774, 794 Table of ContentsTable of ContentsSection 1 To the Installer 1...Water Connect

26Models 750, 751, 754, 774, 794Important: Operator Checklistj 7. If your machine is equipped with an auxiliaryrefrigeration system, check the auxilia

27Models 750, 751, 754, 774, 794 T roubleshooting GuideSection 8 Troubleshooting G uidePROBLEM PROBABLE CAUSE REMEDY PAGEREF.1. No product is beingdis

28Models 750, 751, 754, 774, 794Troubleshooting GuidePROBLEM PROBABLE CAUSE REMEDY PAGEREF.5. The mix in the mix hopperis too warm.a. The temperature

29Models 750, 751, 754, 774, 794 T roubleshooting GuidePROBLEM PROBABLE CAUSE REMEDY PAGEREF.11. Product is not feeding intothe freezing cylinder.a. I

30Models 750, 751, 754, 774, 794Parts Replacement ScheduleSection 9 Parts Replacement SchedulePART DESCRIPTION EVER Y3MONTHSEVERY6MONTHSANNUALLYDrive

Section 10 Parts List31+ Available SeparatelyModels 750, 751, 754, 774, 794 Parts ListHP62 Refrigerant: 750 -- J6110454, 751 -- J6080596, 754 -- J6080

+ Available Separately32Parts List Models 750, 751, 754, 774, 794DESCRIPTION PARTSUPDATEREMARKSW ARR.CLASS794QTY.774QTY.754QTY.751QTY.750QTY.PARTNUMBE

33+ Available SeparatelyModels 750, 751, 754, 774, 794 Parts ListDESCRIPTION PARTSUPDATEREMARKSW ARR.CLASS794QTY.774QTY.754QTY.751QTY.750QTY.PARTNUMBE

+ Available Separately34Parts List Models 750, 751, 754, 774, 794DESCRIPTION PARTSUPDATEREMARKSW ARR.CLASS794QTY.774QTY.754QTY.751QTY.750QTY.PARTNUMBE

35+ Available SeparatelyModels 750, 751, 754, 774, 794 Parts ListDESCRIPTION PARTSUPDATEREMARKSW ARR.CLASS794QTY.774QTY.754QTY.751QTY.750QTY.PARTNUMBE

Table of Contents Models 750, 751, 754, 774, 794Table of Contents -- Page 2Section 6 Operating Procedures 15...Prior

+ Available Separately36Parts List Models 750, 751, 754, 774, 794DESCRIPTION PARTSUPDATEREMARKSW ARR.CLASS794QTY.774QTY.754QTY.751QTY.750QTY.PARTNUMBE

37+ Available SeparatelyModels 750, 751, 754, 774, 794 Parts ListDESCRIPTION PARTSUPDATEREMARKSW ARR.CLASS794QTY.774QTY.754QTY.751QTY.750QTY.PARTNUMBE

+ Available Separately38Parts List Models 750, 751, 754, 774, 794DESCRIPTION PARTSUPDATEREMARKSW ARR.CLASS794QTY.774QTY.754QTY.751QTY.750QTY.PARTNUMBE

39+ Available SeparatelyModels 750, 751, 754, 774, 794 Parts ListDESCRIPTION PARTSUPDATEREMARKSW ARR.CLASS794QTY.774QTY.754QTY.751QTY.750QTY.PARTNUMBE

+ Available Separately40Parts List Models 750, 751, 754, 774, 794DESCRIPTION PARTSUPDATEREMARKSW ARR.CLASS794QTY.774QTY.754QTY.751QTY.750QTY.PARTNUMBE

41+ Available SeparatelyModels 750, 751, 754, 774, 794 Parts ListDESCRIPTION PARTSUPDATEREMARKSW ARR.CLASS794QTY.774QTY.754QTY.751QTY.750QTY.PARTNUMBE

Models 750 & 751052613-27Rev. 10/02

Models 750 & 751052613-33Rev. 10/02

Models 750 & 751052613-40Rev. 10/02

Models 750 & 751052613-58Rev. 10/02

1Models 750, 751, 754, 774, 794 To the Installer050418Section 1 To the InstallerThis machine is designed for indoor use only.DO NOT install the machin

Models 754 & 774046585--27Rev. 10/02

Models 754 & 774046585--33Rev. 10/02

Model 794048199--27Rev. 10/02

Model 794048199--33Rev. 10/02

Model 794048199--62Rev. 10/02

2Models 750, 751, 754, 774, 794To the Operator050818Section 2 To the OperatorThe freezer you have purchased has been carefullyengineered and manufactu

3Models 750, 751, 754, 774, 794 Safety050418Section 3 SafetyWe at Taylor Company are concerned about the safetyof the operator when he or she comes in

4Models 750, 751, 754, 774, 794Operator Parts IdentificationSection 4 Operator Parts IdentificationModel 750Item Description Part No.1 Cover A.-Hopper

5Models 750, 751, 754, 774, 794 Operator Parts IdentificationModel 751Item Description Part No.1 Cover A.-Hopper X384582 Gasket-Hopper Cover 0383753 T