Carrier 58DRC Bedienungsanleitung PDF herunterladen

HEATING & COOLING

58DRC

Counterflow Gas-Fired Furnaces

Installation, Start-Up and Service Instructions

for Sizes 045-095

NOTE. Energy Guide tag may be removed

from furnace when installation is complete.

efficiency

RATING

CGRTIFIED

ama

INTRODUCTION

Before installing the furnace, refer to Procedures for

Gas-Fired Furnaces (packaged with the equipment) for

information concerning combustion, venting, piping,

and other standard installation practices. Further

reference is made to the current edition of the

National Fuel Gas Code, NFPA54-1984/ANSI Z223.1-

1984.

Each furnace is shipped from the factory completely

assembled with multispeed direct-drive blower and wired

ready for counterflow indoor heating installation only.

All sizes feature a printed-circuit board control center

with easy-to-read, low-voltage terminal strip to ensure

proper connections.

A CAUTION

Do not install furnace in a corrosive or contami

nated atmosphere. Make sure all combustion and

circulating air requirements listed in Procedures

for Gas-Fired Furnaces are adhered to, in addition

to all local codes and ordinances.

A CAUTION

Do not block openings in front of furnace or on

furnace top along side vent pipe. These openings pro

vide air for combustion and ventilation. Never store

anything on or in contact with furnace, such as:

aerosol cans, rags, brooms and mops, cleaning tools

and aids, powders, bleaches, waxes, plastic items,

gasoline, kerosene, lighter fluids, cleaning fluids,

thinners, painting compounds or paper products.

The design of the counterflow gas-fired furnace is

A.G.A certified for installation on combustible flooring

(with optional floor base), in alcoves, basements, closets

or utility rooms. This furnace line is not A.G.A. certified

for installation in a mobile home, recreation vehicle, or

outdoors

Installation Procedures: Page

Inspection..........................................................................*

Location, Ventilation and Air

for Combustion................................................................*

Gas Piping.........................................................................*

Venting..............................................................................*

Supply-Air Plenum Installation.........................................1

Electrical Connections.......................................................3

Sequence of Operation.......................................................4

Filter Arrangement

............................................................

Start-Up and Adjustment...................................................6

Care and Maintenance.......................................................6

*Refer to appropiiate sections in Pioceduies foi Gas-Fired Furnaces

packed with this furnace

For accessory installation details, refer to applicable

installation literature.

Fig. 1 — Model 58DRC

Table 1 — Clearances (in.)

SIZE 58DRC

ALL

Single-Wall Vent 1

Type-BI Double-Wall Vent

Back

Top of Plenum 1

Single-Wall

.........

.. Type-B1 Double-Wall 1

„ Combustion Air

’ Service

NOTE. Some furnaces are shipped with paper across the

supply-air outlet. Remove the paper before installing

furnace.

INSTALLATION

Supply-Air Plenum Installation

INSTALLATION ON A CONCRETE SLAB

1 See Fig. 2 for dimensions and location of supply air

opening in furnace bottom

Manufacturer reserves the right to discontinue, or change at any time, specifications or designs without notice and without incurring obiigations.

Bookll 14 PC101 Catalog No 535-843 PrintedinUSA Form58DRC-1SI Pg 1 7-85 Replaces:New

For replacement items use Carrier Specified Parts

Tab |6al8a

1 2 3 4 5 6 7 8 9 10

Inhaltsverzeichnis

Seite 1 - A CAUTION

HEATING & COOLING58DRCCounterflow Gas-Fired FurnacesInstallation, Start-Up and Service Instructionsfor Sizes 045-095NOTE. Energy Guide tag may

Seite 2 - HEATING & COOLING

HEATING A COOLING58DRCCounterflow Gas-Fired FurnacesTO OBTAIN INFORMATION ON PARTS: Consult your Installing dealer or classified section of your local

Seite 3 - A WARNING

HEATING & COOLING58DRCCounterflow Gas-Fired FurnacesTable 2 — Dimensions (in.)SIZE58DRCA BCVENT04517'/2 15% 16 406517'/2 15% 1650802119%

Seite 4 - 7H2 — Auxiliary Limit Switch

HEATING & COOLING58DRCCounterflow Gas-Fired FurnacesFig. 6Furnace, Plenum, and Base Installed on a Combustible FloorElectrical ConnectionsLINE-VOL

Seite 5

HEATING A COOUHG58DRCCounterflow Gas-Fired FurnacesFig. 8 — Amp Draw Check with AmmeterThe room thermostat should be located where it will be

Seite 6

HEATING & COOLING58DRCCounterflow Gas-Fired FurnacesWhen the pilot flame is established, pilot 6H switches its contacts in approximately

Seite 7

HEATING A COOLING58DRCCounterflow Gas-Fired FurnacesSTART-UP AND ADJUSTMENTIn addition to the following information, refer to Procedures for

Seite 8

HEATINC A COOLING58DRCCounterflow Gas-Fired FurnacesThe minimum maintenance that should be performedon this equipment is as follows.1. Check and clea

Seite 9 - Tab )6a

HEATING A COOLING58DRCCounterflow Gas-Fired FurnacesCleaning Heat Exchanger — If it becomes necessary to clean the heat exchanger becaus

Seite 10 - Tab I6al8a

HEATtNG & COOLING58DRCCounterflow Gas-Fired FurnacesTable 6 — Trouble Analysis Chart (cont)SYMPTOM CAUSEREMEDYPilot will not light (cont)Spark sho

Kommentare zu diesen Handbüchern

Keine Kommentare

Carrier 58DRC Bedienungsanleitung

Stöbern Sie online oder laden Sie Bedienungsanleitung nach Grills Carrier 58DRC herunter. Carrier 58DRC User Manual Benutzerhandbuch

Inhaltsverzeichnis

Kommentare zu diesen Handbüchern

Verwandte Produkte und Handbücher für Grills Carrier 58DRC